Product Description
MORTAIR® DPX is a powdered air-entraining agent for use in the production of air entrained mortar.
MORTAIR® DPX is specifically formulated to allow site production of dry silo mortars with air contents complying with EN 998.
MORTAIR® DPX yields a constant air content over a wide range of dosages. MORTAIR® DPX gives an extremely stable air system and complies with EN 934-3.
Advantages
- MORTAIR® DPX produces a stable air system with minimum air loss throughout the life of the plastic mortar
- Production of ready-to-use mortars complying with EN 998 is made easier because of the plateauing of air content and constant air content over a wide range of dosage
- Due to its dosage tolerance, the levels of entrained air when using MORTAIR® DPX are less susceptible to variation in fine aggregate grading and silt content of the fine aggregate
- Mortar containing MORTAIR® DPX has very good site acceptance because of its constant air content, reduced bleeding and predictable workability and life
Typical Properties
MORTAIR® DPX |
Appearance |
Off white powder |
Bulk Density |
900 kg/m3 |
Alkali Content (eq.Na20) |
2.00% |
Chloride Content |
Nil |
Air Entrainment |
See “Addition Rates” |
Freezing Point |
-2⁰C |
Method Of Use
MORTAIR® DPX is supplied ready for use.
It should be added to the mortar mixes during the mixing process at the same time as the water or fine aggregate, but not directly onto cement. With good plant control, very consistent results can be obtained.
The amount of MORTAIR® DPX required is dependent on the characteristics of the mortar constituents and the level of air entrainment required. Factors which affect this are:
- Type and efficiency of the mixing equipment
- Water content
- Fine aggregate content, grading and type
- Cement/lime content and type
- Temperature
Compatibility
With Cements :
MORTAIR® DPX can be used with most types of Portland cements. It is also effective in mortar containing fly ash or ground granulated blastfurnace slag. For use with special cements we recommend contacting GCP Applied Technologies.
With Other Admixtures:
MORTAIR® DPX should not be premixed with other admixtures. The performance of the product will be affected by the presence of other chemical admixtures. We recommend that all admixtures be added separately into the mix.
Addition Rates
Range |
300 ml - 800 ml per 100 kg cement |
0.30% - 0.80% (v/w) by wt. of cement |
As a guide to trials an addition rate of 0.40 - 0.60% volume by weight of cement is suggested. |
For advice and assistance with trials we recommend that you consult GCP Applied Technologies. |
It is essential that preliminary plant trials are performed so that the actual dosage rates can be determined, taking into account the contributing factors stated (where MORTAIR® DPX is used in mortar containing fly-ash, the dosage rate may typically be twice the range quoted above).
Effects of Overdosing
The effect of overdosing MORTAIR® DPX is a function of the degree of overdose.
Overdosing with MORTAIR® DPX will result in a modest increase in air content and workability.
Dispensing
It is preferable that MORTAIR® DPX should be introduced into the mixer by automatic dispensing equipment. Equipment or advice on dispensing can be obtained from GCP Applied Technologies.
Health and Safety
For further information on Health and Safety matters regarding this product we recommend that you consult the relevant Safety Data Sheet from GCP Applied Technologies. In line with general chemical handling precautions avoid contact
with skin or eyes and protective gloves/goggles should be worn.
Packaging
MORTAIR® DPX is supplied in both 25 or 1000 kg bulk bags.
Storage
MORTAIR® DPX should be stored in a cool, dry place protected from rain and extremes of temperature.
Storage Life in Manufacturer‘s Bags:
12 months from date of manufacture.
Technical Service
Our Technical Service department of GCP Applied Technologies is available to assist you in the correct use of our performance chemicals.